Epson C82324* Manual de Serviço Página 98
- Página / 188
- Índice
- RESOLUÇÃO DE PROBLEMAS
- MARCADORES
Avaliado. / 5. Com base em avaliações de clientes
3.2 DISASSEMBLY AND ASSEMBLY
This section describes and illustrates the procedures for disassembling and assembling the
components of the EPL-N2000. The assembly procedures are not described, except for special notes
where necessary, because assembly can be accomplished by performing disassembly in reverse
order.
3.2.1 Outer Covers Removal
This section describes how to remove the left cover, right cover, front cover, top cover, rear cover,
right front cover, right rear cover and the control panel. See the figure below which shows the
location of the covers and screws.
3.2.1.1 Opening the Top Cover
1. Push the blue release lever and open the top cover.
Never touch the following parts when opening the top cover.
❏Fusing unit: It remains hot for a while after the printer stops printing.
❏Transfer Roller: Contact with the roller causes printing deterioration .
❏Dust tight t glass: Contact with the dust tight glass causes printing deterioration .
3.2.1.2 Left Cover Removal
1. Loosen 2 CCS screws (3 X 8) from the top and rear parts of the left cover .
2. Remove the left cover.
3.2.1.3 Right Cover Removal
1. Loosen 3 CCS screws (3 X 8) from the upper part of the right cover.
2. Remove the right cover.
3.2.1.4 Top Cover Removal
1. Remove a screw from the cover.
2. Remove a shoulder screw from the top cover.
3. Remove a CCB screw (3 X 8) from the top cover.
4. Remove the top cover.
CAUTION
Dust Tight Glass
Transfer Roller
Fusing Unit
Disassembly and Assembly EPL-N2000 Service Manual
3-6 Rev. A
- SERVICE MANUAL 1
- Nagano, Japan 2
- PRECAUTIONS 3
- SAFETY INFORMATION 4
- Chapter I, subchapter J 5
- LMERPRODUCTTOIEC825 6
- REVISION SHEET 8
- TABLE OF CONTENTS 9
- Chapter 1 Product Description 10
- List of Figures 11
- List of Tables 12
- 1.1 FEATURES 13
- 1.2 SPECIFICATIONS 16
- Table 1-4. Paper Types 18
- Figure 1-2. Printable Area 19
- Table 1-8. Paper Skew 20
- 1.2.7 Applicable Standards 24
- 1.2.9 Process Specifications 24
- 1.2.12 Fonts Specifications 26
- Table 1-12. Built-in Fonts 27
- In i239X Emulation Mode: 28
- 1.3 INTERFACE SPECIFICATIONS 29
- 1.3.1.3 Network Interface 35
- Protocol 37
- 1.4 OPERATING INSTRUCTIONS 39
- 1.4.2 Panel Settings 41
- Table 1-19. SelecType Options 42
- 1.4.3 Service Mode 48
- 1.4.4 Display of Messages 49
- Table 1-20. Status Messages 49
- Table 1-21. Error Messages 50
- Table 1-22. Warning Messages 58
- Table 1-23. Power On Messages 61
- 1.4.5 Printer Sharing 62
- 1.4.6 Controller RAM Status 63
- Figure 1-8. BiRITech Function 63
- Normal Mode 64
- Toner save mode 64
- Reinforced 64
- Halftone 64
- 1.5 MAIN COMPONENTS 65
- Figure 1-11. C207 MAIN Board 66
- 1-54 Rev. A 66
- 1.5.2 PWB-A Board 67
- 1.5.3 PWB-E Board 67
- Figure 1-12. PWB-A Board 67
- Figure 1-13. PWB-E Board 67
- 1.5.4 PWB-F Board Unit 68
- Figure 1-14. PWB-F Board 68
- 1.5.7 Transfer Unit 69
- Figure 1-17. Transfer Unit 69
- 1.5.9 Fusing Unit 70
- Figure 1-18. Print Head Unit 70
- Figure 1-19. Fusing Unit 70
- 1.5.10 Drive Unit 71
- 1.5.11 Imaging cartridge 71
- Figure 1-20. Drive Unit 71
- Paper takeup roller 72
- Transport roller 72
- Paper size switches 72
- Paper empty sensor 72
- Paper near empty sensor 72
- Table of Contents 73
- 2.1 Engine Operation 74
- 2.1.1 Printing Process 74
- Main Printing Process 74
- Charging Brush 75
- PC Drum Ground 75
- Charge Bias:-1150V (DC) 75
- Figure 2-3. Exposure Process 76
- 2.1.1.3 Developing Process 77
- 2.1.1.4 Transfer Process 78
- Figure 2-5. Transfer Process 78
- Figure 2-6. Fusing Process 79
- 2.1.1.6 Cleaning Process 80
- 2.1.2.1 Fusing Unit 80
- 2.2 Controller Mechanism 83
- Figure 2-11. Laser Control 84
- PWB-A Board 85
- Figure 2-13. Sensor Locations 86
- Rev.A 2-15 88
- 3.1 GENERAL INFORMATION 93
- 3.1.5 Servicing Operations 96
- 3.2 DISASSEMBLY AND ASSEMBLY 98
- Disassembly Note 99
- 3-8 Rev. A 100
- 3.2.2 Fusing Unit Removal 101
- Assembling Note 102
- 3-10 Rev. A 102
- Figure 3-6. Unit Location (1) 103
- 3.2.4.1 Shield Frame Removal 104
- 3-10. Rear Panel Removal 105
- 3.2.5 Rear Panel Removal 105
- Assembly Note 106
- 3.2.8 Printhead Unit Removal 108
- 3.2.8.1 Harness Cover Removal 108
- Connector 109
- Print heat Unit 109
- CCS Screw (3X12) 109
- CB(S-P1) Screw 109
- Paper Empty Sensor Assembly 110
- Rev. A 3-19 111
- Paper Takeup Roller Assembly 112
- CCB Screw (3X8) 113
- Paper Lifting Plate 113
- Assembly Note 115
- 3.2.14 Drive Unit Removal 117
- 3-26 Rev. A 118
- 3.2.15 Heater Lamp Removal 119
- 3.2.15.3 Heater Lamp Removal 120
- Rev. A 3-29 121
- Paper Exit Sensor 122
- Actuator 122
- Lower Fusing Roller 123
- 3.2.19 Thermistor Removal 125
- Thermostat 126
- Front Fusing Cover 126
- CB(S)(P1) Screw (3X6) 126
- Rear Side 126
- Upper Fusing Roller 127
- 3.2.22 Main Motor Removal 128
- Drive Unit (outside) 129
- 3. Remove the solenoid 130
- 3-38 Rev. A 130
- Chapter 4 Adjustment 131
- CHAPTER 5 TROUBLESHOOTING 132
- 5-2 Rev. A 133
- 5.1 OVERVIEW 134
- 5.2 SELF-DIAGNOSTIC FUNCTION 134
- 5.3 TROUBLESHOOTING 136
- CHAPTER 6 MAINTENANCE 146
- 6.1 MAINTENANCE 147
- Appendix 148
- Rev. A A-1 150
- Table A-6 PWB-A CN4 (PWB-E) 154
- Table A-14 PWB-A CN13 156
- A.2 Exploded Diagrams 167
- Figure A-2. Housing 167
- A-18 Rev. A 167
- Figure A-3. Frames 168
- Rev. A A-19 168
- A-20 Rev. A 169
- Rev. A A-21 170
- Figure A-6. Drive Unit 171
- A-22 Rev. A 171
- Fifure A-7. Transfer Unit 172
- Rev. A A-23 172
- Figure A-8. Fusing Unit 173
- A-24 Rev. A 173
- Rev. A A-25 174
- A-26 Rev. A 175
- Rev. A A-27 176
- A-28 Rev. A 177
- Rev. A A-29 178
- A-30 Rev. A 179
- Rev. A A-31 180
- A.4 CIRCUIT DIAGRAMS 181
- EPL-N2000 Service Manual 182
- Rev. A A-34 183
- Rev. A A-35 184
- Rev. A A-36 185
- Rev. A A-37 186
- Figure A-21 186
- C207 MAIN BOARD 186
- (MISC>) 186
- Rev. A A-38 187
Manuais e produtos relacionados com Redes Epson C82324*
Redes Epson GQ-3500 Manual do Utilizador
(27 páginas)
(27 páginas)
Redes Epson SED1278F/D Especificações
(41 páginas)
(41 páginas)
Redes Epson C82305 Manual do Utilizador
(20 páginas)
(20 páginas)
Redes Epson 6200A Manual do Utilizador
(508 páginas)
(508 páginas)
Redes Epson EMP-6000 Guia do Utilizador
(36 páginas)
(36 páginas)
Redes Epson C823151 (Twinax) Guia do Utilizador
(48 páginas)
(48 páginas)
Redes Epson C82324* Guia do Utilizador
(57 páginas)
(57 páginas)
Redes Epson S1C63558 Especificações
(144 páginas)
(144 páginas)
Redes Epson C82332 Guia do Utilizador
(76 páginas)
(76 páginas)
Redes Epson C823301 (Fax I/F) Manual do Utilizador
(17 páginas)
(17 páginas)
Redes Epson S5U1C17801T1100 Manual
(60 páginas)
(60 páginas)
Redes Epson S1C63558 Especificações
(35 páginas)
(35 páginas)
Redes Epson C82314 Guia do Utilizador
(71 páginas)
(71 páginas)
Redes Epson FEH300b Manual do Utilizador
(14 páginas)
(14 páginas)
Redes Epson 6200A Manual do Utilizador
(509 páginas)
(509 páginas)
Redes Epson C823121 (LocalTalk) Manual do Utilizador
(13 páginas)
(13 páginas)
© 2020, manymanuals-pt.com. Todos os direitos reservados. | 0.056 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentários a estes Manuais